View Full Version : Help needed asap!! Wiring help!
09simpss
21-07-12, 04:21 PM
Hi Please some 1 help.
bouch a 1.6 8v vauxhall engine (injection) not sure what out off because got told was gsi motor but doesnt have a dizzy.
iv plumbed it all in just stuck on the wiring (9pin plug) need to know what colours wires do what?
any with diagram please help or with any knowledge
ASAP HELP!
cheers steve
Late gsi's didn't have dizzy's. Have you looked in the articles section? I'm sure there's a guide for them?
Some off the top of my head
Red-perm live
Black-ignition
Green-rev counter
Blue-red-fuel pump
Blue-white-water gauge I think
09simpss
21-07-12, 06:11 PM
Ahh cheers man and I'll take a look.
more importantly, what model of nova are you putting it in... ie, age, engine, was it carb or injection??
what are you doing about the fuel pump/tank etc..?
09simpss
21-07-12, 08:57 PM
Mk1 nova 1.2 carb and got a external electronic fuel pump
well, its a fairly good donor to work with.
wire it up with the original 1.2 sender wires & starter/alternator wiring
then connect off the c16se loom
the red to the starter feed.
the black to the coil feed
the red/blue from the fuel relay to the external pump
then the brown/yellow to the choke light to serve as an EML
and if you have a 6 dial dash
the green is the rev counter
then you'll need a wire to the oil gauge sender
09simpss
24-07-12, 02:16 PM
got running and drives mint.
only thing is sometimes when its starts as soon as u rev its sounds lumpy and cuts out, pain to get started agin? :S
any ideas :)
it could be air getting into the fuel line.
Try turning the key on & off a few times to prime the pump, you can usually hear the air bubbles gushing thru the pipe.
09simpss
25-07-12, 01:33 PM
ok cheers.
only very rarely does this lol.
cheers mowgli big help :)
until you can sort out a proper efi tank, make sure you don't let it go under 1/4 tank, or it can get air up the fuel line on hard cornering.
09simpss
26-07-12, 09:50 AM
been ok so far :)
it will happen when you finally drive it hard enough lol lol
Powered by vBulletin® Version 4.2.5 Copyright © 2024 vBulletin Solutions, Inc. All rights reserved.