View Full Version : injectors inop
MK1_beastie
03-05-10, 07:34 PM
I have got my engine in, it turns over, gets a spark, fuel pump is operating but the injectors are not doing anything.
Can anyone help me on this one? There is fuel at the rail so i know its getting that far :confused:
Oh, its a C20XE
thanks
alan
IS the fuel pump running off the fuel pump relay?
comptoncj
03-05-10, 07:35 PM
All earths tight? would suspect crank sensor or fuel pump relay
MK1_beastie
03-05-10, 07:38 PM
Wow, quick replies! Thanks
Yeah it is running off the fuel pump relay. I did notice a bit of the plastic coating on the crank sensor wiring was melted a little, how many wires are inside or is it a coil type wire?
comptoncj
03-05-10, 07:40 PM
I think there is 3 but not totally sure
Theres 2, the 3rd is a sheild.
MK1_beastie
03-05-10, 07:43 PM
Ok, looks like i should try a new crank sensor...off to the for sale section lol
comptoncj
03-05-10, 07:44 PM
Local motor factors do them for around £35 iirc
If you are getting a spark i doubt its the crank sensor!
comptoncj
03-05-10, 07:48 PM
Have you tried getting the ecu light to flash?
MK1_beastie
03-05-10, 07:49 PM
ok, think i will go and triple check the earths and maybe try give them a clean and see if that helps any.
thanks again
MK1_beastie
06-05-10, 09:18 PM
The car started today!! i took the fuel rail off and bench tested injectors, they were ok and were getting power. Cleaned all the earths as i built it up and changed the fuel pump relay at same time...after a couple of turns it kicked into life :d
oooh good man:thumb: when did you last hear it running? i bet it made your day:d
MK1_beastie
06-05-10, 09:22 PM
Been about 3-4 years since i took the engine out my last nova....so was long overdue. Safe to say i had quite a sizeable cheeser on my face when it started lol
Powered by vBulletin® Version 4.2.5 Copyright © 2024 vBulletin Solutions, Inc. All rights reserved.